3G Book

Section 9 Section 9 Truck Components

Truck Components

Truck Hub Assemblies

Recommended Instructions for Installing Replacement Hubs

These instructions are based on best practice as recommended by OE manufacturers
• All new Hub units should have Seals, O-Rings and locking Rings replaced
• Incorrectly fitted locking rings may cause leakage of oil and will accelerate bearing wear leading

to potential bearing failure.
• It is recommended that new Oil Seals are fitted. Damaged oil seals may cause leakages.
• Replacement of the oil discharge valve on the differential is also recommended. Oil leakage

from the hub unit may occur if the discharge valve is blocked or dirty
• Please be aware that the old hub unit may have caused damage to the driveshaft. We advise

thorough inspection of the driveshaft and replacement where damage or wear is evident
• Inspection of the Brake disc or Brake drum mating surface should be carried out to ensure that

all surfaces are free from grease/lubricants and that no damage as occurred
• We always advise fitting of new Wheel bolts/studs and nuts when replacing hub assemblies
• Care should be taken to follow manufacturer’s guidelines with regards to torque settings for

Axle nuts. Again all parts should be inspected for damage and replaced if necessary
• If the Brake discs are secured to the hub with locking plates, it is important to ensure that all

locking plates can provide suitable ventilation to the Disc/Hubs. Failure to provide adequate
ventilation may cause overheating and premature bearing failure
• We do not advise the use of Re-machined/engineered Brake Discs. It is recommended that new
units are fitted
• We will accept no responsibility for hub failure if these guidelines are not followed.
• Any modifications to the hub assemblies including painting may invalidate the warranty of the
unit

Hubs 450-456 Universal Joints 464 Shock Absorbers 517
Timken Bearings 457-458 Centre Bearings 465-467
Hub Caps & Axles 459 King Pin Kits 468-472 Starter Motors & Alternators 518-519
Dust Covers 459 Steering 473-497
Camshafts 460 Bushes 498-513 Exhaust Parts 520-521
Brake Shoe Platforms 461 Repair Kits 513
Oil Seals 462 Engine Mount 515 Fuel Caps 522
Wheel Studs & Bolts 463 Bolsters 515
Wheel Nuts and Cones 464 Wing Tops / Straps 516 Wiper Blades 523

449

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2400 AH2405 AH2408
Truck Hub c/w Bearings Rear Hub c/w Bearings Front / Rear Hub c/w Bearings

To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1388905 Replaces 1818003 Replaces 1818004

Section 9 Truck Components AH2410 AH2411 AH2416
Rear Hub c/w Bearings Rear Hub w/o Bearings Wheel Hub w/o Bearings

To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1657637 Replaces 1657637 Replaces 1407382

AH2600 AH2601 AH2602
Front Hub w/o Bearings Rear Hub w/o Bearings Rear Hub w/o Bearings

To Fit: Iveco To Fit: Iveco To Fit: Iveco
Replaces 7173316 Replaces 7173696 Replaces 7172993

AH2603 AH2604 AH2605
Front Hub w/o Bearings Rear Hub w/o Bearings Rear Hub w/o Bearings

To Fit: Iveco To Fit: Iveco To Fit: Iveco
Replaces 7182046 Replaces 42115016 Replaces 7186803

450 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2606 AH2607 AH2200
Rear Hub w/o Bearings Front Hub w/o Bearings Front Hub w/o Bearings

To Fit: Iveco To Fit: Iveco To Fit: MAN
Replaces 7179775 Replaces 7188706 Replaces 81365010091

AH2205 AH2210 AH2215 Section 9 Truck Components
Rear Hub c/w Bearings Truck Hub w/o Bearings Truck Hub w/o Bearings

To Fit: MAN To Fit: MAN To Fit: MAN
Replaces 81357010155 Replaces 81357010141 Replaces 81357010081

AH2220 AH2225 AH2230
Truck Hub w/o Bearings Front Hub w/o Bearings Front Hub w/o Bearings

To Fit: MAN To Fit: MAN To Fit: MAN
Replaces 81357010147 Replaces 81443010169 Replaces 81443010136

AH2235 AH2250 AH2255
Front Hub w/o Bearings Front Hub c/w Bearings Rear Hub w/o Bearings

To Fit: MAN To Fit: MAN To Fit: MAN
Replaces 81357010142 Replaces 81934200349 Replaces 81357013152

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 451
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2260 AH2265 AH2270
Rear Hub w/o Bearings Front Flange Hub Front Flange Hub

To Fit: MAN To Fit: MAN To Fit: MAN
Replaces 81357013174 Replaces 81443010177 Replaces 81443010178

Section 9 Truck Components AH2100 AH2101 AH2103
Front Hub c/w Bearings Rear Hub c/w Bearings Rear Hub c/w Bearings

To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes
Replaces 9423340201 Replaces 9763561101 Replaces 9463560201

AH2104 AH2105 AH2106
Rear Hub c/w Bearings Front Hub c/w Bearings Rear Hub c/w Bearings

To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes
Replaces 3560101101 Replaces 6423341001 Replaces 3463563101

AH2107 AH2108 AH2110
Rear Hub c/w Bearings Front Hub c/w Bearings Truck Hub w/o Bearings

To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes
Replaces 9463560701 Replaces 9493340801 Replaces 9423560001

452 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2115 AH2120 AH2130
Truck Hub w/o Bearings Truck Hub w/o Bearings Front Hub c/w Bearings

To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes
Replaces 3463560801 Replaces 3853560601 Replaces 3553340501

AH2135 AH2140 AH2145 Section 9 Truck Components
Front Hub w/o Bearings Front Hub c/w Bearings Front Flange Hub
To Fit: Mercedes
To Fit: Mercedes To Fit: Mercedes Replaces 9703340045
Replaces 6563340201 Replaces 9723300525

AH2150 AH2155 AH2160
Front Flange Hub Front Hub c/w Bearings Front Frange Hub
To Fit: Mercedes To Fit: Mercedes
Replaces 9753300544 To Fit: Mercedes Replaces 9433340945
Replaces 9753300425

AH2165 AH2170 AH2700
Front Hub c/w Bearings Front Hub w/o Bearings Front Hub c/w Bearings

To Fit: Mercedes To Fit: Mercedes To Fit: Renault
Replaces 9433300825 Replaces 6263341001 Replaces 5010566112

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 453
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2705 AH2710 TP5900
Front Hub c/w Bearings Front Hub c/w Bearings Hub Assembly c/w Bearings

To Fit: Renault To Fit: Renault To Fit: Renault
Replaces 7421024160 Replaces 7420535202 Replaces 7420535263

Section 9 Truck Components AH2300 AH2305 AH2315
Rear Hub c/w Bearings Rear Hub c/w Bearings Front Hub c/w Bearings

To Fit: Scania To Fit: Scania To Fit: Scania
Replaces 1382884 Replaces 1800283 Replaces 1868663

AH2316 AH2320 AH2321
Front Hub w/o Bearings Front Hub c/w Bearings Front Hub w/o Bearings

To Fit: Scania To Fit: Scania To Fit: Scania
Replaces 1868663 Replaces 1868674 Replaces 1868674

AH2325 AH2335 AH2000
Rear Hub c/w Bearings Rear Hub w/o Bearings Rear Hub c/w Bearings
To Fit: Scania TAG Axle
To Fit: Scania To Fit: Volvo
Replaces 1255348 Replaces 337563 Replaces 20517952

454 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2006 AH2010 AH2011
Front Hub c/w Bearings Front Hub c/w Bearings Rear Hub c/w Bearings

To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 201022433 Replaces 21024160 Replaces 1626992

AH2012 AH2013 AH2015 Section 9 Truck Components
Front Hub c/w Bearings Rear Hub c/w Bearings Rear/Lift Axle Hub c/w Bearings

To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 20535202 Replaces 85107752 Replaces 20535263

AH2016 AH2017 AH2018
Rear Hub c/w Bearings Front Hub c/w Bearings Front Hub c/w Bearings

To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 20517164 Replaces 85105693 Replaces 85111792

AH2020 AH2021 AH2022
Front Hub c/w Bearings Front Hub c/w Bearings Rear Hub w/o Bearings

To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 85111793 Replaces 5010587029 Replaces 20518054

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 455
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Hubs

AH2023 AH2024 AH2025
Front Hub w/o Bearings Rear Hub c/w Bearings Rear Hub c/w Bearings

To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 20518092 Replaces 20535245 Replaces 21328181

Section 9 Truck Components AH2030 AH2035 AH2040
Front Hub c/w Bearings Front Hub c/w Bearings Rear Hub c/w Bearings

To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 20374418 Replaces 3989341 Replaces 85105696

AH2045
Rear Hub c/w Bearings

To Fit: Volvo
Replaces 20535244

456 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Timken Bearings

TP1503 TP1510 TP1511 TP1512

Timken Bearing Timken Bearing Timken Bearing Timken Bearing
SET1242 32206 SET1177 SET278

To Fit: DAF / Dennis To Fit: DAF LF45 Front Outer To Fit: DAF LF45, Front Inner To Fit: DAF LF45, Front Inner
Replaces DEP102590, 1408086 Replaces 1400078 Replaces 1400081 Replaces 1400075

W:125mm ID:90mm OD:160mm W:21.5mm ID:30mm OD:62mm W:29mm ID:55mm OD:95mm W:30.15mm ID:57.15mm OD:112.7mm

TP1513 TP4600 TP4610 TP7801 Section 9 Truck Components

Timken Bearing Timken Bearing Timken Bearing Timken Bearing
SET1125 SET1352 SET1346 SET1310

To Fit: DAF LF45, Rear To Fit: DAF CF / XF To Fit: DAF CF/XF Front Axle To Fit: Mercedes
Replaces 1404691 Replaces 1801594 Replaces 1699327 Replaces 0003300725

W:22mm ID:66.7mm OD:110mm W:135mm ID:100mm OD:148mm W:114mm ID:69.8mm OD:125mm W:115.5mm ID:82mm OD:140mm

TP5905 TP7100 TP7105 TP1536

Hub Bearing Repair Kit Timken Bearing Timken Bearing Timken Bearing
SET1314 SET1300 SET1301 SET1312

To Fit: Renault To Fit: MAN To Fit: Mercedes To Fit: Volvo
Replaces 7420792439 Replaces 81934200074 Replaces A0059813105 Replaces 20528637

H:135mm ID:93.8mm OD:148mm W:57mm ID:70mm OD:130mm W:57mm ID:70mm OD:130mm W:115mm ID:68mm OD:125mm

TP5200 TP1514 TP1500 TP1515

Timken Bearing Timken Bearing Timken Bearing Timken Bearing
32008XM SET414 SET1231 SET1113

To Fit: Renault To Fit: Scania / Volvo To Fit: Scania 4 Series To Fit: Renault / MAN
Replaces 7703090034 Replaces 291060, 1698580 Replaces 1382900, 1413785 Replaces 5010136769
W:40mm ID:90mm OD:147mm W:41mm ID:65mm OD:120mm
W:19mm ID:40mm OD:68mm ID:68mm OD:127mm

TP1516 TP1530 TP1532 TP1534

Timken Bearing Timken Bearing Timken Bearing Timken Bearing
SET1254 SET1303 SET1091 SET1311
To Fit: DAF To Fit: DAF
To Fit: Meritor To Fit: Renault
Replaces 99041075 Replaces 676988 Replaces 676987 Replaces 7420518617

W:36.51mm ID:82mm OD:140mm W:39mm ID:100mm OD:150mm W:39mm ID:95mm OD:145mm W:115mm ID:58mm OD:110mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 457
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Timken Bearings

TP1517 TP1518 TP1548 TP1538

Timken Bearing Timken Bearing Timken Bearing Timken Bearing
SET1316 SET1079 SET1257 SET1111
To Fit: DAF
To Fit: Mercedes / Scania To Fit: Iveco To Fit: Iveco
Replaces 0129814005 Replaces 00556289, 0626875 Replaces 50005427 Replaces 49816405
W:42.5mm ID:50mm OD:110mm
W:37mm ID:80mm OD:130mm W:125mm ID:90mm OD:160mm W:35mm ID:55mm OD:100mm

Section 9 Truck Components TP1540 TP1542 TP1544 TP1546

Timken Bearing Timken Bearing Timken Bearing Timken Bearing
SET1061 SET1074 SET1351 SET1031
To Fit: DAF
To Fit: DAF / Volvo To Fit: Mercedes To Fit: Iveco
Replaces 1602388, 1652099 Replaces 3129810501 Replaces 1801595 Replaces 1109981

W:30mm ID:60mm OD:100mm W:28.75mm ID:30mm OD:72mm W:110.5mm ID:69.8mm OD:119.7mm W:27mm ID:45mm OD:100mm

TP1550

Timken Bearing
SET1301

To Fit: Mercedes
Replaces 5981315

W:57mm ID:70mm OD:130mm

458 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Hub Caps & Axle Nuts

TP4090 TP4091 TP1280 TP1281

Hub Cap Hub Cap Hub Cap Hub Cap O-Ring
To Fit: DAF CF65,75,85 To Fit: DAF CF65/75/85/XF95/105 To Fit: Scania 4,P,G,R,T Series To Fit: Scania 4,P,G,R,T Series

Replaces 1691965 Replaces 1339107 Replaces 1762224 Replaces 804725

ID:114mm OD:160mm/125mm ID:110mm OD:153mm H:61mm OD:139mm ID:129mm

TP5907 TP5955 TP5956 TP5957 Section 9 Truck Components

Hub Wheel Nut Axle Nut Axle Lock Washer Axle Lock Washer
To Fit: Renault / Volvo To Fit: Renault / Volvo To Fit: Renault / Volvo To Fit: Renault / Volvo
Replaces 7400971088 Replaces 7401076335 Replaces 1077934, 7401077934 Replaces 85157714, 7408157714

H:14mm M14 x 2 Thread: 86 x 2, Spanner 105mm ID:94.5mm OD:130mm ID:87mm OD:132.25mm

Dust Covers

AB0800 AB0801 AB0810 AB0820
Dust Cover FRONT Dust Cover Dust Cover REAR Dust Cover
To Fit: Scania To Fit: Scania
To Fit: Scania Replaces 1378427 To Fit: Scania Replaces: 1378432
Replaces 1378429 W:447mm H:73mm Replaces 1378430 W:447mm H:107mm
W:449mm H:81mm W:449mm H:28mm

AB0850 AB0860 AB0900 AB0901
Dust Cover VL 7’’ Dust Cover VL 8’’ Dust Cover Dust Cover
To Fit: DAF To Fit: DAF
To Fit: Volvo To Fit: Volvo Replaces 1231434 Replaces 1231430
Replaces 20367343 Replaces 1629835 W:463mm H:37mm W:443mm H:49mm
W:446mm H:54mm W:446mm H:66mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 459
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Camshafts

Left hand Right hand

Overall Under Head
Part No: Position O/E Reference Length Length To Fit Position

AC1000 LH 1577453 293mm 261mm Volvo

AC1010 RH 1577452 293mm 261mm Volvo

AC1015 LH 1577451 433mm 401mm Volvo

Section 9 Truck Components AC1020 RH 1577450 433mm 401mm Volvo

AC1025 LH 9524102 330mm 283mm Volvo

AC1030 RH 9524101 330mm 283mm Volvo

AC1100 LH 6234210136 250mm 210mm Mercedes

AC1105 RH 6234210236 250mm 210mm Mercedes

AC1110 LH 6234230236 540mm 500mm Mercedes

AC1115 RH 6234230136 540mm 500mm Mercedes

AC1120 LH 3074230936 454mm 414mm Mercedes

AC1125 RH 3074230836 454mm 414mm Mercedes

AC1130 LH 3054211836 223mm 183mm Mercedes

AC1135 RH 3054211936 223mm 183mm Mercedes

AC1200 LH 1340859 200mm 149mm Scania 3 Series NSF

AC1210 RH 1340860 200mm 149mm Scania 4 Series OSF

AC1220 LH 330639 210mm 158mm Scania 3 Series NSF

AC1230 RH 330640 210mm 158mm Scania 3 Series OSF

AC1240 LH 1342745 453mm 410mm Scania 3 & 4 Series NSF

AC1250 RH 1342746 453mm 410mm Scania 3 & 4 Series OSF

460 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Brake Shoe Platforms

AB1010 Part No: To Fit Type Replaces Lining to suit 3G Lining Ref
AB2000 AB1000 Volvo - Early Pressed 3090075L
AB1001 Volvo - Early Pressed 3090075T VL 86 / 1 (6mm) Leading AL1260
AB1005 Volvo - Late Pressed 3095195L
AB1006 Volvo - Late Pressed 3095195T VL 86 / 1 (6mm) Trailing AL1260
AB1010 Volvo - Late Pressed 3095176L
AB1011 Volvo - Late Pressed 3095176T VL 87 / 1 (5mm) Leading AL1270
AB1012* Volvo - Late Pressed 3090076L
VL 87 / 1 (5mm) Trailing AL1270

VL 88 / 1 (8mm) Leading AL1280

VL 88 / 1 (8mm) Trailing AL1280

VL 88 AL1280

*Brake Shoe Set. c/w AB1010 & AB1011

AB1015 Volvo - Late Pressed 3090077L VL 89 / 1 (8mm) Leading AL1290
VL 89 / 1 (8mm) Trailing AL1290
AB1016 Volvo - Late Pressed 3090077T VL 89 AL1290

AB1017* Volvo - Late Pressed 3090077

*Brake Shoe Set. c/w AB1015 & AB1016

AB1020 Volvo - Late Pressed 68371521 VL 85 / 1 (8mm) Leading AL1250
AL1250
AB1021 Volvo - Late Pressed 68371520 VL 85 / 1 (8mm) Trailing AL1270

AB1007* Volvo - Late Pressed 30900757 VL 87

*Brake Shoe Set. c/w AB1005 & AB1006

AB2000 MAN Cast 81502016075 MP32 AL1000 Section 9 Truck Components
81502016115 MP36 AL1340
AB2001 MAN Cast 6594210208 MP31 AL1320
6594200319 MP32 AL1000
AB2002 MAN/Mercedes Pressed 81502016074 MP36 AL1340
81502016074 MP31 AL1320
AB2010 MAN/Mercedes Pressed 1104543 SV40/1 AL1220
1123136 SV41/1 AL1230
AB2011 MAN/Mercedes Pressed 1104549 SV42/1 AL1240

AB2012 MAN/Mercedes Pressed

AB4000 Scania Cast

AB4001 Scania Cast

AB4002 Scania Cast

Brake Shoe Components

TM1000 TM1001 TM1002 TM1003

Cam Roller Cam Bush Anchor Pin Bush Brake Shoe Pin
To Fit: Scania To Fit: Scania To Fit: Scania To Fit: Scania
Replaces 154259 Replaces 154261 Replaces 154262
Replaces 0141164
W:28mm ID:25mm OD:60mm L:10mm ID:25mm OD:28mm L:54mm OD:25mm
L:19mm ID:31.4mm OD:35mm

TP1120 TM1004 TM1005 TM2000
Cam Bush
To Fit: Scania P, G, R, T Series O-Ring Black O-Ring Red Cam Roller Assembly
Replaces 289336 To Fit: Scania To Fit: Scania To Fit: MAN
Replaces 804665 Replaces 1338019
Replaces 4034200339
ID:33mm H:3mm ID:31mm H:4.5mm
OD:20mm L:76mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 461
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Oil Seals

TP4295 TP4500 TP4505 TP4509

Oil Seal Oil Seal c/w Exciter (100T) Oil Seal Oil Seal
To Fit: DAF LF45 To Fit: DAF To Fit: DAF 95XF To Fit: DAF
Replaces 1400080 Replaces 292766 Replaces 325321
Replaces 1335063
ID:82mm OD:105mm H:10mm ID:124mm OD:160mm H:17mm ID:72mm OD:100mm H:10mm
ID:124mm OD:190/160mm H:21mm

Section 9 Truck Components TP4510 TP4511 TP4512 TP4513

Oil Seal Oil Seal Oil Seal Oil Seal
To Fit: DAF 95XF To Fit: DAF To Fit: DAF 65CF To Fit: DAF 95XF
Replaces 1238034 Replaces 1278421 Replaces 0678157 Replaces 0647330

ID:100mm OD:140mm H:20.5mm ID:90mm OD:140mm H:18mm ID:120mm OD:160mm H:19.5mm ID:100mm OD:135mm H:13mm

TP4514 TP4515 TP5950 TP5951

Oil Seal Oil Seal Hub Seal Ring Hub Seal Ring
To Fit: DAF To Fit: DAF To Fit: Renault To Fit: Renault
Replaces 1278420 Replaces 1400074 Replaces 7401076656 Replaces 7403199066

ID:100mm OD:140mm H:14mm ID:90mm OD:120mm H:13mm ID:98mm OD:111mm H:7mm ID:141mm OD:153mm H:5.5mm

TP5940 TP1600 TP1350 TP5950

Oil Seal Oil Seal Oil Seal Oil Seal
To Fit: Renault To Fit: Scania To Fit: Scania To Fit: Volvo B12,FH/FL/FM
Replaces 5000671980 Replaces 1740992, 1534012 Replaces 1349089
Replaces 1076656
ID:120mm OD:160mm H:15mm ID:142mm OD:17mm H:16mm ID:38.1mm OD:50mm H:6.5mm
ID:98mm OD:111mm H:7mm

462 TP5951
Hub Seal Ring
To Fit: Volvo B12,FH/FL/FM
Replaces 319906

ID:141mm OD:153mm H:5.5mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Wheel Studs and Bolts

TW0100 TW0110 TW0115 TW0120
M22 x 1.5mm M22 x 1.5mm M22 x 1.5mm M22 x 1.5mm
UH:72mm TL:84mm UH:85mm TL:95mm UH:94mm TL:104mm UH:104mm TL:116mm

To Fit: DAF To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1337020 Replaces 1309191 Replaces 1356736 Replaces 1373007
Nut To Suit: TW0125 Nut To Suit: TW0125 Nut To Suit: TW0125 Nut To Suit: TW0125

TW0200 TW0210 TW0300 TW0305 Section 9 Truck Components
M18 x 1.5mm M18 x 1.5mm 7/8” BSF 7/8” BSF
UH:65mm TL:74mm UH:75mm TL:83mm UH:70mm TL:81mm UH:85mm TL:95mm
To Fit: Iveco To Fit: Iveco To Fit: Scania To Fit: Scania
Replaces 42117463 Replaces 42117465 Replaces 397266 Replaces 1528712
Nut To Suit: TW0220 Nut To Suit: TW0220 Nut To Suit: TW0330 Nut To Suit: TW0330

TW0310 TW0320 TW0400 TW0410
7/8” BSF 7/8” BSF 7/8” UNF 7/8” UNF 102mm
UH:86mm TL:98mm UH:102mm TL:12mm UH:86mm TL:96mm UH:102mm TL:112mm
To Fit: Scania To Fit: Scania To Fit: Volvo
Replaces 295953 Replaces 337560 Replaces 1573081 To Fit: Volvo
Nut To Suit: TW0330 Nut To Suit: TW0330 Nut To Suit: TW0430 Replaces 1573082
Nut To Suit: TW0430

TW0420 TW0450 TW0451 TW0452
7/8” UNF M22 x 1.5mm M22 x 1.5mm M22 x 1.5mm
UH:110mm TL:120mm UH:89mm TL:100mm UH:100mm TL:111mm UH:105mm TL:116mm
To Fit: Volvo To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 1589009 Replaces 20515515 Replaces 20515518 Replaces 20515519
Nut To Suit: TW0430 Nut To Suit: TW0440 Nut To Suit: TW0451 Nut To Suit: TW0440

TW0453 TW0455 TW0500 TW0501
M22 x 1.5mm M22 x 1.5mm M22 x 1.5mm M22 x 1.5mm
UH:122mm TL:132mm UH:80mm TL:90mm UH:80mm TL:90mm UH:86mm TL:96mm
To Fit: Volvo To Fit: Volvo/Renault To Fit: Mercedes To Fit: Mercedes
Replaces 20553560 Replaces 20515514 Replaces 3894010071 Replaces 9424010271
Nut To Suit: TW0440 Nut To Suit: TW0440 Nut To Suit: TW0125 Nut To Suit: TW0125

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 463
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Wheel Nuts and Cones

TP5902 TP5903 TW0125 TW0220
M10 x 1.5mm M22 x 1.5mm M22 x 1.5mm M18 x 1.5mm
UH: 97mm TL:107mm L 32mm - AF 32mm L 25mm - AF 27mm
UH:30mm To Fit: Renault To Fit: Iveco
To Fit: Renault Replaces 7420515517 To Fit: DAF Replaces 1373007
Replaces 7401077468 Replaces 1826088

Section 9 Truck Components TW0330 TW0430 TW0440 TP5906
7/8” BSF RH 7/8” UNF M18 x 1.5mm Hub Wheel Cone
L 31mm - AF 33mm L 30mm - AF 33mm M22 x 1.5mm To Fit: Renault / Volvo,
To Fit: Scania To Fit: Volvo To Fit: Volvo Replaces 7401591045
Replaces 318690 Replaces 318690 Replaces 21303956

TE1017 Universal Joints

TE1032 Part No Size (Dia / Length) Application Replaces Replaces Replaces
TE1000 30.2 x 81.8mm Various
TE1025 30.2 x 106.3mm Various 1408363 42546332 5001864205
TE1001 34.9 x 92mm Various
TE1002 34.9 x 106.6mm Various 1404568 42535253 5000295989
TE1035 38 x 148mm Scania
TE1030 38 x 148mm Scania 1409220 99160221
TE1015 38 x 110mm Various
TE1026 41.3 x 126.2mm Various 140547 42537901 5001856095
TE1003 42 x 119.4mm Various
TE1019 42 x 106mm Various 1765828
TE1016 47.6 x 135mm Various
TE1004 48 x 135.4mm Various 1111747
TE1020 48 x 126mm Various
TE1031 48 x 161mm Scania 99192007 81391086052
TE1005 52 x 133mm Various
TE1006 57 x 144mm Various 1404558 42538089 5001837379
TE1017 52 x 147mm Various
TE1018 57 x 152mm Various 1408365 5001867925
TE1032 57 x 164mm Scania
TE1007 57 x 172mm Various 9714100031
TE1027 59 x 167.6mm Various
TE1008 65 x 172mm Various 1404792 42533783 81999178469
TE1034 65 x 190mm Scania
TE1021 68 x 167mm Various 1288224 1451321 81393746004

3854100731 9734100031

1541070

1291683 93159900 81391266021

1252350 99190028 81391266017

1848274 42536996 5001844448

1435479 42536581 9404100031

1797425

1435794 42534502

1608403 42533785 5000803045

1731573 42545298

1541072

6564100131

464 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Centre Bearings

TE1101 TE1103 TE1106 TE1110
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
40 x 168 x 27mm 45 x 168 x 19mm 45 x 194 x 24mm 55 x 190 x 18mm

To Fit: DAF To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1404554 Replaces 1408366 Replaces 1404560 Replaces 1291808

TE1111 TE1112 TE1119 TE1124 Section 9 Truck Components
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
55 x 193.5 x 18mm 55 x 193.5 x 22mm 60 x 220 x 36mm 65 x 200 x 12mm

To Fit: DAF To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1408525 Replaces 1409235 Replaces 1288235 Replaces 1779697

TE1129 TE1132 TE1135 TE1145
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
70 x 220 x 17mm 70 x 220 x 43mm 75 x 220 x 15mm 55x193x18mm

To Fit: DAF To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1235569 Replaces 1288242 Replaces 1288231 Replaces 1409221

TE1146 TE1149 TE1150 TE1151
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
55x200x14mm 50x194x30mm 55 x 200 x 18mm 60 x 200 x 36mm

To Fit: DAF To Fit: DAF To Fit: DAF To Fit: DAF
Replaces 1298157 Replaces 1700326 Replaces 1291808 Replaces 0102204

TE1099 TE1100 TE1142 TE1105
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
35 x 170 x 22mm 40 x 160 x 19mm 100 x 194 x 13mm 45 x 194 x 19mm

To Fit: Iveco To Fit: Iveco To Fit: Iveco To Fit: Iveco
Replaces 42536726 Replaces 42535254 Replaces 93192009 Replaces 42586523

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 465
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Centre Bearings

TE1115 TE1130 TE1136 TE1137
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
60 x 194 x 18mm 70 x 220 x 20mm 70 x 220 x 19mm 75 x 220 x 26mm

To Fit: Iveco To Fit: Iveco To Fit: Iveco To Fit: Iveco
Replaces 42532295 Replaces 42541437 Replaces 93192572 Replaces 42538361

Section 9 Truck Components TE1125 TE1143 TE1144 TE1107
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
65 x 200 x 18mm 35 x 168 x 17mm 40 x 168 x 18mm 45 x 200 x 19mm

To Fit: Iveco To Fit: Iveco To Fit: Iveco To Fit: MAN
Replaces 42541384 Replaces 42541021 Replaces 42536965 Replaces 81394006089

TE1123 TE1126 TE1127 TE1138
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
60 x 194 x 18mm 65 x 220 x 18mm 65 x 220 x 17mm 75 x 230 x 18mm

To Fit: MAN To Fit: MAN To Fit: MAN To Fit: MAN
Replaces 81394106028 Replaces 81394106030 Replaces 81394106019 Replaces 81394106021

TE1139 TE1140 TE1141 TE1102
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
75 x 230 x 26mm 75 x 220 x 26mm 85 x 220 x 26mm 45 x 160 x 18mm
To Fit: Mercedes
To Fit: MAN To Fit: MAN To Fit: MAN Replaces 9704110012
Replaces 81394106032 Replaces 81394106037 Replaces 81394106034

TE1104 TE1108 TE1109 TE1114
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
45 x 190 x 23mm 55 x 190 x 23mm 55 x 190 x 25mm 60 x 190 x 22mm
To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes
Replaces 3814101522 Replaces 9734100012 Replaces 9734100022 Replaces 6544110012

466 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Centre Bearings

TE1120 TE1128 TE1134 TE1165
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
60 x 247 x 25mm 70 x 190 x 20mm 70 x 242 x 25mm 45 x 195 x 19mm
To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes To Fit: Mercedes
Replaces 3894101422 Replaces 6564110012 Replaces 3954100622 Replaces 9014110415

TE1166 TE1117 TE1118 TE1121 Section 9 Truck Components
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
47 x 222 x 21mm 65 x 220 x 35.5mm 65 x 219 x 36mm
To Fit: Mercedes To Fit: Renault To Fit: Renault 60 x 22mm
Replaces 9064101381 Replaces 5000819211 Replaces 5001866236 To Fit: Scania
Replaces 1113031

TE1122 TE1113 TE1116 TE1131
Centre Bearing Centre Bearing Centre Bearing Centre Bearing
55 x 200 x 18mm 60 x 198 x 30mm 70 x 220 x 20mm
60 x 26mm
To Fit: Scania To Fit: Volvo To Fit: Volvo To Fit: Volvo
Replaces 1387764 Replaces 1068208 Replaces 1696389 Replaces 1068222

TE1133
Centre Bearing
70 x 220 x 26mm

To Fit: Volvo
Replaces 21082632

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 467
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

To Fit: DAF KIng Pin Kits Part No: TP4020
To Fit: DAF
For full kit use TP4020 Part No: TP4201 Model: CF/XF, XF95
To Fit: DAF Set: Axle
Section 9 Truck Components Model: CF/XF, XF95
Set: 1/2 Axle Replaces: 0681706
Pin Dim: 50/31.5mm x 270mm
Replaces: 0681706
Pin Dim: 50/31.5mm x 270mm Part No: TP4205
To Fit: DAF
Part No: TP4206 Model: XF95, MKII
To Fit: DAF Set: Axle
Model: XF95, MKII
Set: 1/2 Axle Replaces: 0683499
Pin Dim: 50/31.5mm x 254mm
Replaces: 0683499
Pin Dim: 50/31.5mm x 254mm

For full kit use TP4205 Part No: TP4209 Part No: TP4210
For full kit use TP4210 To Fit: DAF To Fit: DAF
Model: LF45 Model: LF45
Set: 1/2 Axle Set: Axle

Replaces: 0683469 Replaces: 0683469
Pin Dim: 32/40mm x 171mm Pin Dim: 32/40mm x 171mm

Part No: TP4216 Part No: TP4215
To Fit: DAF To Fit: DAF
Model: CF85 Model: CF85
Set: 1/2 Axle Set: Axle

Replaces: 1895526 Replaces: 0683470
Pin Dim: 40.5mm x 266mm Pin Dim: 40.5mm x 266mm

For full kit use TP4215

Part No: TP4220 Part No: TP4204
To Fit: DAF To Fit: DAF
Model: LF55 Model: LF45 10/12T
Set: 1/2 Axle Set: 1/2 Axle

Replaces: 1895527 Replaces: 0683590

Pin Dim: 45mm x 214mm Pin Dim: 40.4mm x 266mm

To fit 10T Axle

468 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

KIng Pin Kits

Part No: TP4211
To Fit: DAF
Model: 45/Road Runner
Set: 1/2 Axle

Replaces: KPK8
Pin Dim: 25/31.5mm x 165mm

To Fit: Iveco Part No: TP2255 Part No: TP2256 Section 9 Truck Components
To Fit: MAN To Fit: Iveco To Fit: Iveco
Model: Eurocargo 65, Model: Eurocargo
75E Set: 1/2 Axle
Set: Axle
Replaces: 1904698
Replaces: 1904696 Pin Dim: 43/53mm x 227mm
Pin Dim: 28/35mm x 178mm
Part No: TP3208
Part No: TP3090 To Fit: MAN
To Fit: MAN Model: L2000, M2000
Model: TGL Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 81442056023
Replaces: 81442056034 Pin Dim: 51/50mm x 222.5mm
Pin Dim: 43mm x 200mm

Part No: TP3200 Part No: TP3209
To Fit: MAN To Fit: MAN
Model: TGA, TGA, TGL, Model: L2000
TGS Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 81442056025
Replaces: 81442056030
Pin Dim: 36/35mm x 172mm
Pin Dim: 53/52mm x 235mm

Part No: TP3210 Part No: TP3211
To Fit: MAN To Fit: MAN
Model: L2000 Model: G90
TGL, TGM Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 81442056016
Replaces: 81442056033
Pin Dim: 35mm x 174mm
Pin Dim: 42/41.5mm x 202mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 469
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

To Fit: Mercedes KIng Pin Kits ORDER ONLINE
www.3gttp.com
Part No: TP3220
To Fit: Mercedes Part No: TP7600
Model: Vario To Fit: Mercedes
Set: 1/2 Axle Model: Sprinter
Set: 1/2 Axle
Replaces: 3103301219
6683300019 Replaces: 6113300419
Pin Dim: 26mm x 136mm
Pin Dim: 270mm x 154mm

Section 9 Truck Components Part No: TP7610 Part No: TP7611
To Fit: Mercedes To Fit: Mercedes
Model: Actros Model: Actros
04/96 - 10/02 04/96 - 10/02
Set: 1/2 Axle Set: 1/2 Axle

Replaces 655330619 Replaces: 6553300719

Pin Dim: 50mm x 222.5mm Pin Dim: 50mm x 222.5mm

Part No: TP7612 Part No: TP7613
To Fit: Mercedes To Fit: Mercedes
Model: Actros Model: Actros
Set: 1/2 Axle Set: 1/2 Axle

Replaces: 6553300519S Replaces: 6553300419S

Pin Dim: 50mm x 222.5mm Pin Dim: 50mm x 222.5mm

To Fit: Renault

Part No: TP5800 Part No: TP5802
To Fit: Renault To Fit: Renault
Model: Midliner S100, Model: S170, 130,
110, 120, 125, 150TI, 170
130 Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 5000336305,
Replaces: 5000793641 5000794185

Pin Dim: 28mm x 153mm Pin Dim: 35mm x 178mm

Part No: TP5803 Part No: TP5804
To Fit: Renault To Fit: Renault
Model: Premium to 1989 Model: Midliner, S140,
Maxter, Premium S160, S120/135
2000 on Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 500033606
Replaces: 5010056002
5010630994 Pin Dim: 30mm x 167mm

Pin Dim: 50mm x 225mm

470 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

KIng Pin Kits

To Fit: Renault Cont’d

Part No: TP5805 Part No: TP5809
To Fit: Renault To Fit: Renault
Model: AE420ti, AE520, Model: Premium
Premium TR4 X2 2006 +
Set: 1/2 Axle Set: 1/2 Axle

Replaces: 5010216742 Replaces: 500185610
5010630993 Pin Dim: 28/27.5mm x 155mm

Pin Dim: 50mm x 236mm Part No: TP5811
To Fit: Renault
Part No: TP5810 Model: Midliner M140, Section 9 Truck Components
To Fit: Renault 160, 200, 230
Model: Midlum Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 5000784185
Replaces: 5010630991 5000794319

Pin Dim: 35mm x 179mm Pin Dim: 40mm x 236mm

To Fit: Scania Part No: TP5812 Part No: TP1155
To Fit: Renault To Fit: Scania
Model: Midliner G210, Model: 4 Series P/R/T
230, 260, 290 Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 550257, 550284
Replaces: 5000793828 Pin Dim: 40/50mm x 223mm
Pin Dim: 40mm x 241mm

Part No: TP1150
To Fit: Scania
Model: 3 Series
Set: 1/2 Axle

Replaces: 550730
Pin Dim: 44.5/55mm x 215mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 471
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

To Fit: Volvo KIng Pin Kits ORDER ONLINE
www.3gttp.com
Section 9 Truck Components Part No: TP8070
To Fit: Volvo Part No: TP8105
Model: Volvo FM9, 12, To Fit: Volvo
FH12, 16, NH12, Model: Volvo FL6
B12B Set: 1/2 Axle
Set: 1/2 Axle
Replaces: 276193
Replaces: 20751021 Pin Dim: 40/45mm x 220mm
Pin Dim: 40/53mm x 237mm
Part No: TP8301
Part No: TP8300 To Fit: Volvo
To Fit: Volvo Model: F10, 12,16,
Model: F7,10,12,16, FH16, FL6, 7, 10
FL6,7,10,12 12, FM7, 10, 12
Set: 1/2 Axle Set: 1/2 Axle

Replaces: 276024, 276030 Replaces: 271142, 276023
276032, 270911 276031, 276912
271141, 276015
Pin Dim: 36/50mm x 252mm
Pin Dim: 37/48mm x 237mm
Part No: TP8310
Part No: TP8305 To Fit: Volvo
To Fit: Volvo Model: FH12,M16,
Model: FM7, FL10, FM7, 10,12
FM10 Set: 1/2 Axle

Axle Set: 1/2 Axle Replaces: 3092467
Replaces: 1699357 Pin Dim: 50/51mm x 233mm
Pin Dim: 50/48mm x 269mm

Part No: TP8315 Part No: TP8320
To Fit: Volvo To Fit: Volvo
Model: FM7, 9, 10, 12, Model: FL6
FH12, 16, NH12, Set: 1/2 Axle
B7, 9, 12, FL6
Set: 1/2 Axle Replaces: 270920

Replaces: 3093731 Pin Dim: 35/45mm x 195mm
Pin Dim: 60/40mm x 232mm

Part No: TP8321
To Fit: Volvo
Model: FE Series
Set: 1/2 Axle

Replaces: 20590486
85108338

Pin Dim: 60/40mm x 227zmm

472 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Steering

Length

Thread B

Thread A

Ball Joints

Part No Vehicle OEM 1 OEM 2 Thread A Thread B (RH/LH) Length M/F Section 9 Truck Components
TA1000 Mercedes 0004605748 0004606048 M27 x 1.5 M30 x 1.5 (RH) 120mm Male
TA1001 Mercedes 0004606948 0004606148 M14 x 1.5 M30 x 1.5 (LH) 120mm Male
TA1002 Mercedes 0014605048 0014604248 M20 x 1.5 M28 x 1.5 (RH) 140mm Male
TA1005 Volvo 1698846 1507823 M20 x 1.5 M30 x 1.5 (RH) 120mm Male
TA1095 Volvo 1507822 1698533 M20 x 1.5 M30 x 1.5 (LH) 120mm Male
TA1010 Volvo 1698558 1698840 M24 x 1.5 M30 x 1.5 (LH) 120mm Male
TA1140 Volvo 0356310 1507826 M24 x 1.5 M30 x 1.5 (RH) 120mm Male
TA1015 DAF 651648-3 Nak3395 M20 x 1.5 M30 x 1.5 (LH) 120mm Male
TA1100 DAF, Leyland NAK3394 653910 M20 x 1.5 M30 x 1.5 (RH) 125mm Male
TA1020 DAF, Ford Cargo, Iveco, 6851517000 1326986 M20 x 1.5 M30 x 1.5 (RH) 120mm Male
Leyland, MAN,
Mercedes, Renault, Volvo 42493782 2984511 M20 x 1.5 M30 x 1.5 (LH) 115mm Male
TA1090 DAF, Ford Cargo,
Iveco, Leyland, MAN, 0607053 0014601448 M24 x 1.5 M30 x 1.5 (LH) 120mm Male
Mercedes, Renault,
Volvo 8226236059 6851475000 M24 x 1.5 M30 x 1.5 (RH) 140mm Male
TA1025 DAF, Ford Cargo, Iveco,
Leyland, MAN, Mercedes 0607452 0110196 M18 x 1.5 M28 x 1.5 (LH) 105mm Male
Renault, Scania, Volvo ACU9240 - M18 x 1.5 M28 x 1.5 (RH) 180mm Male
TA1045 DAF, Dennis Ford Cargo, 0608530 0004633229 M16 x 1.5 M24 x 1.5 (RH) 95mm Male
Leyland, MAN, Mercedes,
Renault, Scania, Seddon 5001867774 5001866165 M24 x 1.5 M32 x 1.5 (RH) 140mm Male
TA1030 Volvo 42480023 8193649 M16 x 1.5 M24 x 1.5 (LH) 95mm Male
TA1120 DAF Leyland 42487165 8558527 M18 x 1.5 M24 x 1.5 (RH) 105mm Male
TA1035 Ford, Cargo, MAN, 7984276 8558524 M18 x 1.5 M24 x 1.5 (LH) 105mm Male
Mercedes 1689604 - M20 x 1.5 M28 x 1.5 (RH) 115mm Male
TA1058 Renault 1689605 - - M28 x 1.5 (LH) 115mm Male
TA1060 Man, Ford Cargo 20374698 - M20 x 1.5 M26 x 1.5 (RH) 88mm Male
TA1055 Volvo, Mercedes 3097228 2264701 M20 x 1.5 M30 x 1.5 (RH) 145mm Male
TA1065 Man, Ford Cargo 21263821 3093647 M20 x 1.5 M30 x 1.5 (RH) 140mm Male
TA1070 DAF, Leyland 20710008 - M24 x 1.5 M30 x 1.5 (LH) 140mm Male
TA1075 DAF, Leyland 20581089 3452701 M24 x 1.5 M30 x 1.5 (RH) 140mm Male
TA1076 Volvo 3090727 3988965 M16 x 1.5 M30 x 1.5 (RH) 115mm Male
TA1077 Volvo 3090728 3988968 M16 x 1.5 M30 x 1.5 (LH) 115mm Male
TA1078 Volvo 0067303 - M24 x 1.5 M48 x 1.5 (LH) 140mm Female
TA1080 Volvo 0067389 - M24 x 1.5 M48 x 1.5 (RH) 140mm Female
TA1081 Volvo 1622238 - M24 x 1.5 M24 x 1.5 (RH) 95mm Female
TA1105 Volvo Bus 1401942 - M18 x 1.5 M30 x 1.5 (RH) 120mm Male
TA1110 Volvo Bus
TA1125 DAF
TA1130 DAF
TA1148 DAF / Foden
TA1150 DAF LF45

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 473
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

Steering ORDER ONLINE
www.3gttp.com
Length
Thread B

Thread A

Ball Joints

Section 9 Truck Components Part No Vehicle OEM 1 OEM 2 Thread A Thread B (RH/LH) Length M/F
TA1152 DAF 1401944 AFRA635 M18 x 1.5 M30 x 1.5 (LH) 120mm Male
TA1153 DAF 1603883 41149875 M24 x 1.5 M30 x 1.5 (RH) 150mm Male
TA1154 DAF 1403899 199091 M24 x 1.5 M30 x 1.5 (LH) 125mm Male
TA1155 DAF 1400157 1604248 M20 x 1.5 M28 x 1.5 (RH) 148mm Male
TA1156 DAF 1400158 1604247 M20 x 1.5 M28 x 1.5 (LH) 148mm Male
TA1158 DAF 1389190 - M20 x 1.5 M30 x 1.5 (RH) 150mm Male
TA1040 DAF, Dennis, Ford Cargo, 0110197 0607451 M18 x 1.5 M28 X 1.5 (RH) 105mm Male
Leyland, MAN, Mercedes,
Renault 81953016095 81953016071 M24 x 1.5 M26 x 1.5 (RH) 95mm Female
TA1050 Mercedes, Scania, Volvo 1357674 1738479 M24 x 1.5 M30 x 1.5 (RH) 150mm Male
TA1085 Scania ACU9239 LE39 M18 x 1.5 M28 x 1.5 (LH) 180mm Male
TA1115 DAF, Leyland 0003301035 0003381610 M14 x 1.5 M24 x 1.5 (RH) 95mm Male
TA1135 Mercedes 0223712 1361618 M30 x 1.5 M26 x 1.5 (RH) 85mm Male
TA1145 Mercedes, Volvo

V-Stays

Part No Description Vehicle OEM 1 OEM 2 OEM 3 Tube Diameter Length
662mm
TB1020 V-Stay Volvo 20428251 20491771 20507262 48mm 677mm
671mm
TB1021 V-Stay Volvo 20556490 3173291 48mm 677mm
760mm
TB1022 V-Stay Volvo 20829503 20392649 1629234 58mm 662mm
662mm
TB1024 V-Stay Volvo 3172829 48mm
622mm
TB1026 V-Stay Volvo 70376894 3193895 24426048 48mm 667mm
622mm
TB1027 V-Stay Volvo 20556608 20703338 20491771 50mm 622mm
608mm
TB1028 V-Stay Volvo 20589061 20703338 50mm 603mm

TC1065 V-Stay MAN 81432206221 81432706096 81432706114

TB1062 V-Stay Mercedes 9423501605 9423500705 3753500105 46mm

TB1063 V-Stay Mercedes 9483502805 A9483502805 60mm

TB1066 V-Stay Mercedes 9443500305 9483503005 9473500705 46mm

TB1067 V-Stay Mercedes 9473501005 9423501505 9423501505 46mm

TC1200 V-Stay DAF 1361652 1620436 48mm

TC1205 V-Stay DAF 649819 1793877 1620437 50mm

474 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Steering - Drag Links

Part No: TA1159
Ball Joint To Suit: TA1045

Vehicle: DAF 95
OEM 1: 0094038
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 1015mm
(Centre to Centre in Straight Line)

Part No: TA1160
Ball Joint To Suit: TA1045

Vehicle: DAF 95
OEM 1: 0094037
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 998mm
(Centre to Centre in Straight Line)

Part No: TB1070 Section 9 Truck Components
Ball Joint To Suit: TA1020

Vehicle: DAF CF75/85
OEM 1: 1283211
OEM 2: 1351714
OEM 3: 1385497
Tube Diameter: 52mm
Length: 876mm

(Centre to Centre in Straight Line)

Part No: TB1071
Ball Joint To Suit: TA1155 / TA1156

Vehicle: DAF
OEM 1: 1407963
OEM 2: 1405823
OEM 3: 1400156
Tube Diameter: 40mm
Length: 1640mm
(Centre to Centre in Straight Line)

Part No: TB1072
Ball Joint To Suit: -

Vehicle: DAF 75CF - 98 On
OEM 1: 1315530
OEM 2: 1351731
OEM 3: 1385506
Tube Diameter: 52mm
Length: 1658mm
(Centre to Centre in Straight Line)

Part No: TB1073
Ball Joint To Suit: TA1045

Vehicle: DAF 95/95XF
OEM 1: 1426101
OEM 2:

OEM 3:
Tube Diameter: 52mm

Length: 1004mm

(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 475
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Drag Links

476 Part No: TB1074
Ball Joint To Suit: TA1045 / TA1025

Vehicle: DAF X95/XF105/CF75/85
OEM 1: 1451119
OEM 2:
OEM 3:
Tube Diameter: 38mm
Length: 590mm
(Centre to Centre in Straight Line)

Part No: TB1075
Ball Joint To Suit: TA1020

Vehicle: DAF 65/95/85CF
OEM 1: 1351715
OEM 2: 1283212
OEM 3: 1385492
Tube Diameter: 52mm
Length: 848mm
(Centre to Centre in Straight Line)

Part No: TB1076
Ball Joint To Suit: TA1154

Vehicle: DAF
OEM 1: 1405309
OEM 2: 1403898
OEM 3:
Tube Diameter: 46mm
Length: 926mm
(Centre to Centre in Straight Line)

Part No: TB1077
Ball Joint To Suit: TA1045

Vehicle: DAF 65/75/85CF
OEM 1: 1448063
OEM 2: 1602821
OEM 3:
Tube Diameter: 50mm
Length: 867mm
(Centre to Centre in Straight Line)

Part No: TB1078
Ball Joint To Suit: TA1045

Vehicle: DAF CF75/85
OEM 1: 1363858
OEM 2: 1602820
OEM 3:
Tube Diameter: 50mm
Length: 855mm
(Centre to Centre in Straight Line)

Part No: TB1079
Ball Joint To Suit: TA1152

Vehicle: DAF LF45
OEM 1: 1406038
OEM 2: 1700914
OEM 3:
Tube Diameter: 38mm
Length: 895mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
477
Steering - Drag Links

Part No: TB1080
Ball Joint To Suit: TA1152

Vehicle: DAF LF45
OEM 1: 1407144
OEM 2: 1700912
OEM 3:
Tube Diameter: 39mm
Length: 880mm
(Centre to Centre in Straight Line)

Part No: TB1081
Ball Joint To Suit: TA1045

Vehicle: DAF 95XF/CF75/85
OEM 1: 1380417
OEM 2: 1451129
OEM 3:
Tube Diameter: 36mm
Length: 860mm
(Centre to Centre in Straight Line)

Part No: TB1083
Ball Joint To Suit: TA1090 / TA1020

Vehicle: DAF XF105/XF95/95XF
OEM 1: 1351205
OEM 2: 1353395
OEM 3:
Tube Diameter: 40mm
Length: 1646mm
(Centre to Centre in Straight Line)

Part No: TB1084
Ball Joint To Suit: -

Vehicle: DAF CF75/CF85
OEM 1: 1373879
OEM 2: 1448065
OEM 3:
Tube Diameter: 52mm
Length: 865mm
(Centre to Centre in Straight Line)

Part No: TB1094
Ball Joint To Suit: TA1205

Vehicle: DAF LF55
OEM 1: 1405363
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 909mm
(Centre to Centre in Straight Line)

Part No: TB1101
Ball Joint To Suit: TA1045

Vehicle: DAF XF95/XF105
OEM 1: 1395993
OEM 2:
OEM 3:
Tube Diameter: 38mm
Length: 996mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Drag Links

Part No: TB1102
Ball Joint To Suit: TA1045

Vehicle: DAF XF95/XF105
OEM 1: 1395994
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 991mm
(Centre to Centre in Straight Line)

Part No: TB1103
Ball Joint To Suit: -

Vehicle: DAF CF75/CF85
OEM 1: 1451122
OEM 2:
OEM 3:
Tube Diameter: 52mm
Length: 1977mm
(Centre to Centre in Straight Line)

Part No: TB1135
Ball Joint To Suit: TA1020

Vehicle: DAF 75CF/85CF
OEM 1: 1385493
OEM 2: 1257991
OEM 3: 1351718
Tube Diameter: 36mm
Length: 860mm
(Centre to Centre in Straight Line)

Part No: TB1104
Ball Joint To Suit: -

Vehicle: DAF LF55
OEM 1: 1407774
OEM 2:
OEM 3:
Tube Diameter: 41mm
Length: 919mm
(Centre to Centre in Straight Line)

Part No: TC1014
Ball Joint To Suit: TA1020

Vehicle: DAF 95XF
OEM 1: 1385499
OEM 2: 1351734
OEM 3: 1291060
Tube Diameter: 52mm
Length: 1005mm
(Centre to Centre in Straight Line)

Part No: TB1105
Ball Joint To Suit: TA1040

Vehicle: Ford Cargo
OEM 1: 1663962
OEM 2:
OEM 3:
Tube Diameter: 36mm
Length: 820mm
(Centre to Centre in Straight Line)

478 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
479
Steering - Drag Links

Part No: TB1010
Ball Joint To Suit: TA1045

Vehicle: Iveco Eurostar / Tech
OEM 1: 41005463
OEM 2: 8131582
OEM 3: 8132397
Tube Diameter: 42mm
Length: 865mm
(Centre to Centre in Straight Line)

Part No: TB1085
Ball Joint To Suit: TA1020

Vehicle: Iveco Eurocargo 1991 On
OEM 1: 98467459
OEM 2: 98402544
OEM 3:
Tube Diameter: 38mm
Length: 822mm
(Centre to Centre in Straight Line)

Part No: TB1115
Ball Joint To Suit: TA1020

Vehicle: Iveco Eurocargo
OEM 1: 4854874
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 897mm
(Centre to Centre in Straight Line):

Part No: TC1029
Ball Joint To Suit: TA1025, TA1045

Vehicle: Iveco Eurocargo
OEM 1: 504034521
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 1570mm
(Centre to Centre in Straight Line)

Part No: TC1030
Ball Joint To Suit: TA1045

Vehicle: Iveco Eurocargo
OEM 1: 98469650
OEM 2: 98449025
OEM 3:
Tube Diameter: 42mm
Length: 878mm
(Centre to Centre in Straight Line)

Part No: TC1031
Ball Joint To Suit: TA1045

Vehicle: Iveco Eurocargo
OEM 1: 98446354
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 900mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Drag Links

480 Part No: TC1033
Ball Joint To Suit: TA1020

Vehicle: Iveco Eurocargo
OEM 1: 500324282
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 785mm
(Centre to Centre in Straight Line)

Part No: TB1090
Ball Joint To Suit: TA1035

Vehicle: MAN L2000
OEM 1: 81466106725
OEM 2: 85466106102
OEM 3:
Tube Diameter: 32mm
Length: 826mm
(Centre to Centre in Straight Line)

Part No: TB1098
Ball Joint To Suit: TA1045

Vehicle: MAN TG Series
OEM 1: 81466116198
OEM 2: 81466116197
OEM 3: 81466116133
Tube Diameter: 52mm
Length: 995mm
(Centre to Centre in Straight Line)

Part No: TB1065
Ball Joint To Suit: TA1002

Vehicle: Mercedes Actros
OEM 1: 0024604505
OEM 2: 0024604605
OEM 3:
Tube Diameter: 36mm
Length: 895mm
(Centre to Centre in Straight Line)

Part No: TB1095
Ball Joint To Suit: TA1215

Vehicle: Mercedes LK/LN2
OEM 1: 6734600305
OEM 2: 6734600505
OEM 3: 6734600705
Tube Diameter: 36mm
Length: 725mm
(Centre to Centre in Straight Line)

Part No: TB1100
Ball Joint To Suit: TA1040

Vehicle: Mercedes Vario
OEM 1: 6674601605
OEM 2: 6674601805
OEM 3:
Tube Diameter: 34mm
Length: 504mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
481
Steering - Drag Links

Part No: TB1140
Ball Joint To Suit: TA1020

Vehicle: Mercedes Atego
OEM 1: 9704600805
OEM 2: 9704601005
OEM 3:
Tube Diameter: 42mm
Length: 846mm
(Centre to Centre in Straight Line)

Part No: TB1142
Ball Joint To Suit: TA1045

Vehicle: Mercedes Actros MP2/MP3
OEM 1: A0024604805
OEM 2: 0024604805
OEM 3:
Tube Diameter: 40mm
Length: 875mm
(Centre to Centre in Straight Line)

Part No: TB1030
Ball Joint To Suit: TA1002

Vehicle: Mercedes Actros
OEM 1: 0024604305
OEM 2: 0024604405
OEM 3:
Tube Diameter: 36mm
Length: 879mm
(Centre to Centre in Straight Line)

Part No: TB1143
Ball Joint To Suit: TA1000

Vehicle: Mercedes MP2/MP3
OEM 1: 9493300603
OEM 2: A9493300603
OEM 3:
Tube Diameter: 52mm
Length: 1687mm
(Centre to Centre in Straight Line)

Part No: TB1144
Ball Joint To Suit: TA1220

Vehicle: Mercedes Atego
OEM 1: 0024604905
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 895mm
(Centre to Centre in Straight Line)

Part No: TB1145
Ball Joint To Suit: TA1045

Vehicle: Renault Premium
OEM 1: 5010294288
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 845mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Drag Links

Part No: TB1146
Ball Joint To Suit: TA1045

Vehicle: Mercedes Atego
OEM 1: 9744601105
OEM 2: 9744601305
OEM 3:
Tube Diameter: 50mm
Length: 894mm
(Centre to Centre in Straight Line)

Part No: TB1147
Ball Joint To Suit: TA1020

Vehicle: Mercedes Atego
OEM 1: 9704601105
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 846mm
(Centre to Centre in Straight Line)

Part No: TB1148
Ball Joint To Suit: TA1045

Vehicle: Mercedes Atego
OEM 1: 0034604605
OEM 2: 3754600005
OEM 3: 9744601205
Tube Diameter: 50mm
Length: 895mm
(Centre to Centre in Straight Line)

Part No: TB1149
Ball Joint To Suit: TA1020

Vehicle: Mercedes Atego
OEM 1: 9724601405
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 837mm
(Centre to Centre in Straight Line)

Part No: TB1151
Ball Joint To Suit: -

Vehicle: Mercedes Actros MP2/MP3
OEM 1: 0034603205
OEM 2: 0024600505
OEM 3: 0014601305
Tube Diameter: 42mm
Length: 1095mm
(Centre to Centre in Straight Line)

Part No: TB1152
Ball Joint To Suit: TA1000

Vehicle: Mercedes Actros
OEM 1: 0024608805
OEM 2: 0024608905
OEM 3:
Tube Diameter: 38mm
Length: 716mm
(Centre to Centre in Straight Line)

482 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
483
Steering - Drag Links

Part No: TB1153
Ball Joint To Suit: TA1045, TA1025

Vehicle: Mercedes Tourismo/Setra
OEM 1: 6293300003
OEM 2: 6293300603
OEM 3:
Tube Diameter: 38mm
Length: 880mm
(Centre to Centre in Straight Line)

Part No: TB1154
Ball Joint To Suit: TA1045, TA1025

Vehicle: Mercedes Actros MP2/MP3
OEM 1: 9423302503
OEM 2: 9423301703
OEM 3: 9423301003
Tube Diameter: 38mm
Length: 1281mm
(Centre to Centre in Straight Line)

Part No: TB1155
Ball Joint To Suit: TA1000

Vehicle: Mercedes MK
OEM 1: 0014602905
OEM 2: A0014602905
OEM 3:
Tube Diameter: 52mm
Length: 840mm
(Centre to Centre in Straight Line)

Part No: TB1110
Ball Joint To Suit: TA1045

Vehicle: Renault Premium
OEM 1: 5010294287
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 809mm
(Centre to Centre in Straight Line)

Part No: TB1111
Ball Joint To Suit: -

Vehicle: Renault Premium
OEM 1: 5001868389
OEM 2: 5010647032
OEM 3: 5010647033
Tube Diameter: 62mm
Length: 825mm
(Centre to Centre in Straight Line)

Part No: TB1000
Ball Joint To Suit: TA1045

Vehicle: Scania 3 Series
OEM 1: 1304571
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 920mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Drag Links

Part No: TB1005
Ball Joint To Suit: TA1045

Vehicle: Scania 4 Series
OEM 1: 1384025
OEM 2: 1379071
OEM 3:
Tube Diameter: 52mm
Length: 1060mm
(Centre to Centre in Straight Line)

Part No: TB1050
Ball Joint To Suit: TA1085

Vehicle: Scania P,G,R,T
OEM 1: 1394884
OEM 2: 1343268
OEM 3:
Tube Diameter: 40mm
Length: 433mm
(Centre to Centre in Straight Line)

Part No: TB1051
Ball Joint To Suit: -

Vehicle: Scania P,G,R,T
OEM 1: 1343278
OEM 2:
OEM 3:
Tube Diameter: 62mm
Length: 2783mm
(Centre to Centre in Straight Line)

Part No: TB1052
Ball Joint To Suit: -

Vehicle: Scania P,G,R,T
OEM 1: 1423007
OEM 2: 1765384
OEM 3:
Tube Diameter: 62mm
Length: 2783mm
(Centre to Centre in Straight Line)

Part No: TB1053
Ball Joint To Suit: -

Vehicle: Scania P,G,R,T
OEM 1: 1386618
OEM 2:
OEM 3:
Tube Diameter: 62mm
Length: 2179mm
(Centre to Centre in Straight Line)

Part No: TB1200
Ball Joint To Suit: TA1025, TA1085

Vehicle: Scania P,G,R,T
OEM 1: 1343283
OEM 2: 1759691
OEM 3:
Tube Diameter: 38mm
Length: 435mm
(Centre to Centre in Straight Line)

484 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
485
Steering - Drag Links

Part No: TB1120
Ball Joint To Suit: TA1045

Vehicle: Scania P,G,R,T
OEM 1: 1384027
OEM 2: 1379072
OEM 3: 1912758
Tube Diameter: 52mm
Length: 1059mm
(Centre to Centre in Straight Line)

Part No: TB1125
Ball Joint To Suit: -

Vehicle: Scania P,G,R,T,1st Recovery
OEM 1: 1343264
OEM 2: 1732635
OEM 3:
Tube Diameter: 60mm
Length: 1921mm
(Centre to Centre in Straight Line)

Part No: TB1130
Ball Joint To Suit: TA1025, TA1045

Vehicle: Scania P,G,R,T,2nd Relay
OEM 1: 1343266
OEM 2: 1759690
OEM 3:
Tube Diameter: 40mm
Length: 495mm
(Centre to Centre in Straight Line)

Part No: TB1025
Ball Joint To Suit: TA1005

Vehicle: Volvo FH16
OEM 1: 20393079
OEM 2: 1628635
OEM 3: 3988708
Tube Diameter: 50mm
Length: 875mm
(Centre to Centre in Straight Line)

Part No: TB1039
Ball Joint To Suit: TA1010, TA1140

Vehicle: Volvo FM10
OEM 1: 1194824
OEM 2: 1626672
OEM 3:
Tube Diameter: 42mm
Length: 822mm
(Centre to Centre in Straight Line)

Part No: TB1040
Ball Joint To Suit: TA1005

Vehicle: Volvo FM7
OEM 1: 1075664
OEM 2: 20393063
OEM 3: 3988701
Tube Diameter: 52mm
Length: 861mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Drag Links

Part No: TB1041
Ball Joint To Suit: -

Vehicle: Volvo FM300/330/340/360
OEM 1: 20367555
OEM 2:
OEM 3:
Tube Diameter:
Length: 160mm
(Centre to Centre in Straight Line)

Part No: TB1045
Ball Joint To Suit: TA1140

Vehicle: Volvo B10M
OEM 1: 1135630
OEM 2: 3013947
OEM 3:
Tube Diameter: 56mm
Length: 1106mm
(Centre to Centre in Straight Line)

Part No: TB1049
Ball Joint To Suit: TA1078

Vehicle: Volvo FH400
OEM 1: 20393187
OEM 2: 21106952
OEM 3:
Tube Diameter: 52mm
Length: 863mm
(Centre to Centre in Straight Line)

Part No: TB1033
Ball Joint To Suit: -

Vehicle: Volvo FH12/FH16/FM4/FM12
OEM 1: 20260283
OEM 2: 20383081
OEM 3: TA1078
Tube Diameter: 48mm
Length: 485mm
(Centre to Centre in Straight Line)

Part No: TB1034
Ball Joint To Suit: -

Vehicle: Volvo FH/FM
OEM 1: 20453064
OEM 2: 20584291
OEM 3:
Tube Diameter: 62mm
Length: 2139mm
(Centre to Centre in Straight Line)

Part No: TB1035
Ball Joint To Suit: TA1200

Vehicle: Volvo FL6
OEM 1: 6799190
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 893mm
(Centre to Centre in Straight Line)

486 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com

Steering - Drag Links

Part No: TB1036
Ball Joint To Suit: TA1078

Vehicle: Volvo FM12
OEM 1: 20374831
OEM 2: 21252480
OEM 3:
Tube Diameter: 48mm
Length: 563mm
(Centre to Centre in Straight Line)

Part No: TB1037
Ball Joint To Suit: TA1005

Vehicle: Volvo FM7/FM10/FM12
OEM 1: 20393067
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 868mm
(Centre to Centre in Straight Line)

Part No: TB1038
Ball Joint To Suit: -

Vehicle: Volvo FH12/FM12
OEM 1: 3199225
OEM 2: 24425662
OEM 3: 20513953
Tube Diameter: 50mm
Length: 868mm
(Centre to Centre in Straight Line)

Part No: TB1055
Ball Joint To Suit: TA1140

Vehicle: Volvo FL7
OEM 1:
OEM 2:
OEM 3: 1592940
Tube Diameter: 50mm
Length: 810mm
(Centre to Centre in Straight Line)

Part No: TB1060
Ball Joint To Suit: TA1140

Vehicle: Volvo B10M/MKII/MKIV
OEM 1: 8132373
OEM 2:
OEM 3:
Tube Diameter: 62mm
Length: 1022mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 487
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Track Rods

488 Part No: TB1068
Ball Joint To Suit: TA1045, TA1025

Vehicle: DAF XF95/CF75/CF85
OEM 1: 1451118
OEM 2:
OEM 3:
Tube Diameter: 38mm
Length: 860mm
(Centre to Centre in Straight Line)

Part No: TB1069
Ball Joint To Suit: TA1153

Vehicle: DAF 55LF
OEM 1: 1408040
OEM 2: 1400056
OEM 3: 1706037
Tube Diameter: 50mm
Length: 1691mm
(Centre to Centre in Straight Line)

Part No: TB1087
Ball Joint To Suit: TA1025, TA1045

Vehicle: DAF CF65/75/85
OEM 1: 1700001
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 1734mm
(Centre to Centre in Straight Line)

Part No: TB1088
Ball Joint To Suit: TA1025, TA1045

Vehicle: DAF XF105/CF75/CF85
OEM 1: 1732972
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 1646mm
(Centre to Centre in Straight Line)

Part No: TB1089
Ball Joint To Suit: -

Vehicle: DAF
OEM 1: 1426375
OEM 2: 1451126
OEM 3:
Tube Diameter: 36mm
Length: 1054mm
(Centre to Centre in Straight Line)

Part No: TB1091
Ball Joint To Suit: TA1230

Vehicle: DAF LF55
OEM 1: 1407470
OEM 2:
OEM 3:
Tube Diameter: 41mm
Length: 925mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
489
Steering - Track Rods

Part No: TB1092
Ball Joint To Suit: -

Vehicle: DAF LF45
OEM 1: 1407688
OEM 2: 1408245
OEM 3:
Tube Diameter: 38mm
Length: 898mm
(Centre to Centre in Straight Line)

Part No: TB1093
Ball Joint To Suit: TA1158

Vehicle: DAF 85CF/F2100
OEM 1: 1295415
OEM 2: 1353400
OEM 3: 1361157
Tube Diameter: 52mm
Length: 1733mm
(Centre to Centre in Straight Line)

Part No: TC1015
Ball Joint To Suit: TA1158

Vehicle: DAF 95XF/CF75/85
OEM 1: 1297572
OEM 2: 1361155
OEM 3:
Tube Diameter: 52mm
Length: 1512mm
(Centre to Centre in Straight Line)

Part No: TC1016
Ball Joint To Suit: TA1158

Vehicle: DAF 95XF/95
OEM 1: 1286343
OEM 2:
OEM 3:
Tube Diameter: 52mm
Length: 1698mm
(Centre to Centre in Straight Line)

Part No: TC1017
Ball Joint To Suit: TA1085

Vehicle: DAF XF105/CF75/85
OEM 1: 1732980
OEM 2:
OEM 3:
Tube Diameter: 52mm
Length: 1522mm
(Centre to Centre in Straight Line)

Part No: TC1018
Ball Joint To Suit: TTA1090, TA1020

Vehicle: DAF XF105/XF95/95XF
OEM 1: 1270854
OEM 2: 1337644
OEM 3:
Tube Diameter: 40mm
Length: 1742mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Track Rods

Part No: TC1025
Ball Joint To Suit: TA1090, TA1020

Vehicle: DAF 95XF/CF65/CF75
OEM 1: 1270853
OEM 2: 1353391
OEM 3:
Tube Diameter: 40mm
Length: 1690mm
(Centre to Centre in Straight Line)

Part No: TC1026
Ball Joint To Suit: -

Vehicle: DAF XF105/XF95
OEM 1: 1396000
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 1952mm
(Centre to Centre in Straight Line)

Part No: TC1050
Ball Joint To Suit: TA1090, TA1020

Vehicle: Iveco Eurocargo
OEM 1: 500307556
OEM 2: 98402553
OEM 3:
Tube Diameter: 38mm
Length: 1490mm
(Centre to Centre in Straight Line)

Part No: TC1028
Ball Joint To Suit: TA1025, TA1045

Vehicle: Iveco Stralis
OEM 1: 8163773
OEM 2: 4102730
OEM 3: 4103694
Tube Diameter: 48mm
Length: 1620mm
(Centre to Centre in Straight Line)

Part No: TB1096
Ball Joint To Suit: TA1040

Vehicle: MAN TGA/L2000/M2000
OEM 1: 85466106021
OEM 2: 85466106121
OEM 3: 85466106247
Tube Diameter: 22mm
Length: 853mm
(Centre to Centre in Straight Line)

Part No: TB1097
Ball Joint To Suit: TA1210

Vehicle: MAN TGA
OEM 1: 81467116858
OEM 2: 81467116860
OEM 3: 81467116863
Tube Diameter: 52mm
Length: 1680mm
(Centre to Centre in Straight Line)

490 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
491
Steering - Track Rods

Part No: TB1099
Ball Joint To Suit: -

Vehicle: MAN TGS
OEM 1: 81467106355
OEM 2: 81467106356
OEM 3: 81467116794
Tube Diameter: 42mm
Length: 1680mm
(Centre to Centre in Straight Line)

Part No: TC1062
Ball Joint To Suit: TA1060, TA1035

Vehicle: MAN L2000
OEM 1: 81467116728
OEM 2: 81467106866
OEM 3: 81467106865
Tube Diameter: 30mm
Length: 1670mm
(Centre to Centre in Straight Line)

Part No: TC1063
Ball Joint To Suit: TA1030, TA1040

Vehicle: MAN L2000
OEM 1: 81467116841
OEM 2: 81467116719
OEM 3: 81467116729
Tube Diameter: 35mm
Length: 1630mm
(Centre to Centre in Straight Line)

Part No: TC1064
Ball Joint To Suit: -

Vehicle: MAN 18.223/18.263
OEM 1: 81467116844
OEM 2: 81467116778
OEM 3: 81467116732
Tube Diameter: 50mm
Length: 1729mm
(Centre to Centre in Straight Line)

Part No: TB1156
Ball Joint To Suit: -

Vehicle: Mercedes Econic
OEM 1: 9574600205
OEM 2: 9574601005
OEM 3: A9574600205
Tube Diameter: 38mm
Length: 514mm

Part No: TB1157
Ball Joint To Suit: TA1065, TA1055

Vehicle: Mercedes T2 Vario 86-94
OEM 1: 6703300603
OEM 2: 6703300403
OEM 3: 6703300303
Tube Diameter: 38mm
Length: 1594mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Track Rods

Part No: TC1034 *Adjustable Both Sides
Ball Joint To Suit: TA1030, TA1040

Vehicle: Mercedes Atego
OEM 1: 6763300703
OEM 2: 6763300903
OEM 3:
Tube Diameter: 40mm
Length: 1550mm
(Centre to Centre in Straight Line)

Part No: TC1035
Ball Joint To Suit: TA1000

Vehicle: Mercedes Actros
OEM 1: 9423300003
OEM 2: 9423300103
OEM 3: 9423300203
Tube Diameter: 52mm
Length: 1735mm
(Centre to Centre in Straight Line)

Part No: TC1150
Ball Joint To Suit: TA1045

Vehicle: Renault Premium 2
OEM 1: 7421560963
OEM 2: 5010587039
OEM 3: 5010587034
Tube Diameter: 60mm
Length: 1686mm
(Centre to Centre in Straight Line)

Part No: TC1000
Ball Joint To Suit: TA1045

Vehicle: Scania P,G,R,T
OEM 1: 1385251
OEM 2: 1409918
OEM 3: 1723865
Tube Diameter: 50mm
Length: 1743mm
(Centre to Centre in Straight Line)

Part No: TC1010
Ball Joint To Suit: TA1025, TA1045

Vehicle: Scania 4 Series
OEM 1: 1734020
OEM 2: 1397866
OEM 3: 395350
Tube Diameter: 40mm
Length: 1736mm
(Centre to Centre in Straight Line)

Part No: TC1011
Ball Joint To Suit: -

Vehicle: Scania P,G,R,T
OEM 1: 1527989
OEM 2: 1723896
OEM 3: 1897336
Tube Diameter: 52mm
Length: 1743mm
(Centre to Centre in Straight Line)

492 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com

Steering - Track Rods

Part No: TC1100
Ball Joint To Suit: TA1225

Vehicle: Volvo FH12
OEM 1: 3985571
OEM 2: 1612254
OEM 3: 20393097
Tube Diameter: 58mm
Length: 1640mm
(Centre to Centre in Straight Line)

Part No: TC1101
Ball Joint To Suit: TA1095, TA1005

Vehicle: Volvo FH12,FH16,FM7,FM9,FM10
OEM 1: 1628637
OEM 2: 3962343
OEM 3: 3988711
Tube Diameter: 42mm
Length: 1640mm
(Centre to Centre in Straight Line)

Steering - Anti Roll Bar

Part No: TC1020
Ball Joint To Suit: TA1100

OEM 1: Volvo FM10
OEM 2: 1629668
OEM 3: 3986433
Tube Diameter: 20477805
Length: 30mm
(Centre to Centre in Straight Line) 325mm

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 493
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Torque Rods

494 Part No: TC1005
Repair Kit To Suit: TP4185

Vehicle: DAF CF75/CF85
OEM 1: 1294251
OEM 2:
OEM 3:
Tube Diameter: 42mm
Length: 606mm
(Centre to Centre in Straight Line)

Part No: TC1019
Repair Kit To Suit: TP4184

Vehicle: DAF XF105,XF95,CF75/85
OEM 1: 1261101
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 390mm
(Centre to Centre in Straight Line)

Part No: TC1027
Repair Kit To Suit: TP3280

Vehicle: Iveco Stralis/Trakker
OEM 1: 8137027
OEM 2:
OEM 3:
Tube Diameter: 40mm
Length: 594mm
(Centre to Centre in Straight Line)

Part No: TC1040
Repair Kit To Suit: TD1005

Vehicle: Scania P,G,R,T / 4 Series
OEM 1: 1326775
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 522mm
(Centre to Centre in Straight Line)

Part No: TC1041
Repair Kit To Suit: TD1005

Vehicle: Scania 4 Series
OEM 1: 1399182
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 580mm
(Centre to Centre in Straight Line)

Part No: TC1060
Repair Kit To Suit: -

Vehicle: MAN TG Series
OEM 1: 81432206247
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 414mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE Section 9 Truck Components
www.3gttp.com
495
Steering - Torque Rods

Part No: TC1061
Repair Kit To Suit: TP3286

Vehicle: MAN TG Series
OEM 1: 81432206229
OEM 2: 81432206305
OEM 3: 81432206304
Tube Diameter: 48mm
Length: 572mm
(Centre to Centre in Straight Line)

Part No: TC1042
Repair Kit To Suit: TD1005

Vehicle: Scania 4 Series
OEM 1: 1367281
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 522mm
(Centre to Centre in Straight Line)

Part No: TC1044
Repair Kit To Suit: TP1245

Vehicle: Scania 4 Series
OEM 1: 1428347
OEM 2:
OEM 3:
Tube Diameter: 85mm
Length: 568mm
(Centre to Centre in Straight Line)

Part No: TC1045
Repair Kit To Suit: TD1260, TD1005

Vehicle: Scania P,G,R,T
OEM 1: 1399180
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 568mm
(Centre to Centre in Straight Line)

Part No: TC1046
Repair Kit To Suit: TP3282

Vehicle: Scania P,G,R,T
OEM 1: 1485758
OEM 2: 1486757
OEM 3:
Tube Diameter: 46mm
Length: 568.5mm
(Centre to Centre in Straight Line)

Part No: TC1047
Repair Kit To Suit: TD1005

Vehicle: Scania P,G,R,T
OEM 1: 1782023
OEM 2:
OEM 3:
Tube Diameter: 48mm
Length: 568.5mm
(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Section 9 Truck Components Steering - Torque Rods Rear Lower
Rear Upper
Part No: TC1051 Rear Upper
Repair Kit To Suit: TP3284 Rear Lower
Rear Lower
Vehicle: Scania P,G,R,T Rear Lower
OEM 1: 1722750
OEM 2: 1499478
OEM 3: 1485760
Tube Diameter: 50mm
Length: 617mm
(Centre to Centre in Straight Line)

Part No: TC1052
Repair Kit To Suit: TP3284

Vehicle: Scania P,G,R,T
OEM 1: 1499474
OEM 2:
OEM 3:
Tube Diameter: 50mm
Length: 568mm
(Centre to Centre in Straight Line)

Part No: TC1053
Repair Kit To Suit: TD1015

Vehicle: Scania P,G,R,T
OEM 1: 1486758
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 522mm
(Centre to Centre in Straight Line)

Part No: TC1054
Ball Joint To Suit: TP3282

Vehicle: Scania P,G,R,T
OEM 1: 1485753
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 523mm
(Centre to Centre in Straight Line)

Part No: TC1055
Ball Joint To Suit: TP3282

Vehicle: Scania P,G,R,T
OEM 1: 1485759
OEM 2:
OEM 3:
Tube Diameter: 46mm
Length: 580mm
(Centre to Centre in Straight Line)

Part No: TC1056
Ball Joint To Suit: TD1015

Vehicle: Scania P,G,R,T
OEM 1: 1486756
OEM 2:
OEM 3:
Tube Diameter:
Length: 568mm
(Centre to Centre in Straight Line)

496 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Steering - Torque Rods Upper Rear Front

Part No: TC1057
Ball Joint To Suit: TD1000

Vehicle: Scania 4 Series
OEM 1: 1494296
Tube Diameter: 46mm
Length: 552mm
(Centre to Centre in Straight Line)

Part No: TB1042 Front Section 9 Truck Components
Repair Kit To Suit: TD1005
Rear
Vehicle: Volvo FH400/440 Front
OEM 1: 20410053 Rear
OEM 2: 21106157
OEM 3:
Tube Diameter: 48mm
Length: 799mm
(Centre to Centre in Straight Line)

Steering - Stabiliser Rods

Part No: TB1015
Description: Stabiliser Rod

Vehicle: Volvo FM7/FM12
OEM 1: 3987354
OEM 2: 3173613
Tube Diameter: 36mm
Length: 435mm
(Centre to Centre in Straight Line)

Part No: TB1016
Description: Stabiliser Rod

Vehicle: Volvo FM9/12/FH12
OEM 1: 20443061
OEM 2: 20443065
OEM 3: 21237061
Tube Diameter: 36mm
Length: 435mm
(Centre to Centre in Straight Line)

Part No: TB1017
Description: Stabiliser Rod

Vehicle: Volvo FM9/12/FH12
OEM 1: 20443062
Tube Diameter: 36mm
Length: 380mm
(Centre to Centre in Straight Line)

Part No: TB1018 Rear
Description: Stabiliser Rod

Vehicle: Volvo FH400/420/440/460/480
OEM 1: 20043067
OEM 2: 20443063
OEM 3: 20994420
Tube Diameter: 36mm
Length: 350mm

(Centre to Centre in Straight Line)

Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply 497
or constitute a binding agreement as to the manufacturing origin of the goods supplied.

ORDER ONLINE
www.3gttp.com

Truck Components

TP4000 TP4005 TP4001 TP4002
Spring Bush (Early)
Spring Bush (Late) Spring Bush Spring Bush
To Fit: DAF Cf65 Cfd75 Cf85 Xf95 To Fit: DAF Cf75 Cf85 Xf95 Xf105 To Fit: DAF To Fit: DAF LF
Replaces 1357764 Replaces 1368283 Replaces 1401465
Replaces 1671219
L:86mm ID:24mm OD:63mm L:106mm ID:24mm OD:63mm L:76mm ID:22mm OD:51.5mm
L:86mm ID:24mm OD:61mm

Section 9 Truck Components TP4003 TP4004 TP4009 TP4011

Spring Bush Spring Bush Spring Brush Spring Bush
To Fit: DAF LF To Fit: DAF To Fit: DAF LF45 To Fit: DAF
Replaces 1401131 Replaces 1611229 Replaces 1401539 Replaces 1401516

L:133mm ID:32mm OD:86mm L:83mm ID:24mm OD:60mm L:82mm ID:17mm OD:46mm L:82mm ID:17mm OD:49mm

TP4190 TP4006 TP4007 TP4012

Spring Eye Bush & Pin Spring Bush Spring Bush Spring Bush
To Fit: DAF To Fit: DAF Cf85 Cf85 Xf105 Xf95 To Fit: DAF To Fit: DAF
Replaces 0654792 Replaces 1401489
Replaces 1401487 Replaces 1681114
L:144mm OD:50mm L:97mm ID:19mm OD:52mm
Bore Distance:122mm OD:90.5mm Bore Distance:128mm OD:61mm

TP2110 TP2145 TP2246 TP2315

Spring Bush Spring Bush Spring Bush Spring Bush
To Fit: Iveco Daily To Fit: Iveco Eurotech To Fit: Iveco To Fit: Iveco Eurocargo
Replaces 8587681 Replaces 8160686, 2997221 Replaces 504112265
Replaces 98413847
L:40mm W:40mm ID:16.5mm L:89.5mm ID:36mm OD:62mm L:87mm ID:16.5mm OD:55mm
L:74mm ID:16mm OD:47mm

TP2320 TP2395 TP2475 TP2535

Spring Bush Spring Bush Spring Bush Spring Bush
To Fit: Iveco To Fit: Iveco Eurocargo To Fit: Iveco Eurocargo To Fit: Iveco Eurocargo
Replaces 98513847 Replaces 504011462
Replaces 98482540 Replaces 8160687
L:74mm ID:16mm OD:48mm L:80mm ID:16.5mm OD:64.5mm
L:40mm ID:16.5mm OD:45.5/65mm L:107mm ID:20.2mm OD:62.3mm

498 Part numbers and product codes of suppliers other than ‘3G’ are quoted for cross reference purposes only and do not imply
or constitute a binding agreement as to the manufacturing origin of the goods supplied.